Located east of the Seyhan River, Yüreğir is one of Adana's large districts carrying both the farming and the industrial load. Cotton and citrus fields, organised industrial areas and heavy commercial-vehicle traffic exist side by side here. These conditions create a special challenge for auto AC systems: dust. At Temel Servis we provide auto AC gas refill, compressor-condenser repair and cleaning of dust-clogged systems to passenger and light commercial vehicles in Yüreğir.
In areas with farmland and dirt roads, the dust density in the air is far higher than in the city centre. This dust builds up in two places: on the condenser fins and in the pollen filter. When the condenser is clogged the AC gas cannot cool enough and cooling weakens; when the pollen filter is full airflow drops and more dust enters the cabin. During harvest periods and on windy days this build-up accelerates further. For drivers in Yüreğir, cleaning the AC filter and condenser at short intervals is more important than in the city centre.
Pickups, panel vans and agricultural transport vehicles are common in Yüreğir. These vehicles work long hours under load and in the heat, and their AC systems are exposed to the same pace. Depending on your model, R134a or new-generation R1234yf gas is used. Before refilling we evacuate the existing gas with a vacuum, run a leak test, and then charge the manufacturer's specified amount together with compressor oil using a precision device. Efficient AC operation in commercial vehicles is important not only for comfort but for long-distance safety; a tired driver loses concentration much faster in the heat.
In AC units that constantly run at full load, the compressor is the part that tires most. Clutch wear, a bearing noise, or cooling that suddenly cuts out can be compressor-related. The condenser is the part most worn by Yüreğir's dust and soil conditions; its fins both clog and can be crushed by road material. Pressurised cleaning of the fins markedly improves cooling in most cases; if there is a dent or a hole, the condenser must be renewed. We assess both parts with manometer and thermometer readings and do not recommend a part unless it is truly needed.
In a vehicle working in a dusty environment the pollen filter fills much faster than normal. When the filter clogs, airflow does not just drop; moisture and dust build up on the evaporator, leading to odor-causing bacteria and mold. A musty smell from the AC is common in vehicles working in agricultural areas. We renew the pollen filter and apply disinfectant to the evaporator to clean the odor source. If you work in dusty conditions we recommend planning filter changes more often; this protects both cooling and cabin air quality.
If the AC stops cooling again shortly, there is a leak in the system. In vehicles working on vibrating, dusty roads the union connections and o-rings can loosen more quickly. By introducing UV dye or nitrogen pressure we locate the leak and solve the seepage permanently rather than just adding gas. Since the AC system is linked to the auto-electrical system, we also check the fan, relay and sensors. To see your car's general condition you can look at our Adana auto service and Adana service guide pages, and for AC and electrical details our Adana auto AC and auto-electrical page.
Our workshop is in Seyhan's Fevzipaşa neighbourhood, easily reachable from Yüreğir. While we are Opel and Chevrolet specialists, we provide AC service for all makes of passenger and light commercial vehicle. We know the needs of vehicles working in dusty conditions and do the work based on measurement and transparency. For our service in the neighbouring district you can look at our Ceyhan auto AC service page. For an appointment call 0533 662 01 00. Address: Fevzipaşa Mah. 48057. Sk. No:16/A, 01355 Seyhan/Adana.
You need to change it more often than the standard recommendation. Because the filter fills very quickly in agricultural and dusty areas, it is one of the first parts to check when cooling weakens.
The basic principles are the same, but because commercial vehicles work under load for longer, the system tires more. That is why we check the compressor and condenser more carefully.
Yes. A dust-clogged condenser cannot cool the gas enough. Cleaning the fins brings cooling performance back markedly in most cases; a part replacement may not be needed.
The filter that fills in a dusty environment and moisture building up on the evaporator lead to microorganism growth. Filter replacement and evaporator disinfection remove this smell.
Our workshop is in Seyhan Fevzipaşa and is a short trip from Yüreğir. By booking an appointment you can have the work done without waiting.